Home |
Search |
Today's Posts |
|
Electronics Repair (sci.electronics.repair) Discussion of repairing electronic equipment. Topics include requests for assistance, where to obtain servicing information and parts, techniques for diagnosis and repair, and annecdotes about success, failures and problems. |
Reply |
|
LinkBack | Thread Tools | Display Modes |
#1
|
|||
|
|||
32' Sony tv KV-32V16,chassis:SCC-F85R-A
32" Sony PIP stereo tv model:KV-32V16,chassis:SCC-F85R-A &
AA-1,year:Nov 1995.After about 3 hours of running or so the tv shuts off and when power button is pressed the tv turns on for 1 second then shuts off again,when power button is pressed again it turns of for a few minutes then starts the process all over until the tv is allowed to cool down for a few hours. The standby LED light is not blinking so I cannot pull the codes,I found extensive cracked solder joints throughout the unit and I resoldered,the solder in the horizontal section was fine believe it or not but I resoldered it as well. This unit uses Flyback # 8-451-315-41 or 1-439-498-71 Here are other models which share the same chassis: Chassis: AA-1 Model : KV-27S10 / 15 KV-27TS29 / 29 / 32 / 36 KV-27TW77 / 78 KV-27V10 / 15 / 55 KV-27XBR37 / 45 KV-32S10 / 12 / 15 / 16 KV-32TS36 / 46 KV-32TW67 / 68 / 77 / 78 KV-32V15 / 16 KV-32XBR37 / 45 / 85 Taken from: http://www.iwaynet.net/~nesda/SonyCross.html Thanks in advance for help. |
#2
|
|||
|
|||
32' Sony tv KV-32V16,chassis:SCC-F85R-A
If the set shuts after it gets warmed up and will restart when cold, I
would be looking for thermo sensitive components. The electrolytic caps in the scans and power supply in many sets are known for this type of fault. You can use a heat gun, and freeze-mist cooling spray to help troubleshoot for thermo sensitive components. Each time you cool the suspect parts, you will have to recycle the power, to see if it will start again. One method I use is to heat the suspect caps with a heat gun, and then test them with an ESR meter while they are still hot. This is a bit easier, depending on the accessibility of the underside of the board in this approach, and the situation. -- Greetings, Jerry Greenberg GLG Technologies GLG ============================================== WebPage http://www.zoom-one.com Electronics http://www.zoom-one.com/electron.htm Instruments http://www.zoom-one.com/glgtech.htm ============================================== "Sidney" wrote in message om... 32" Sony PIP stereo tv model:KV-32V16,chassis:SCC-F85R-A & AA-1,year:Nov 1995.After about 3 hours of running or so the tv shuts off and when power button is pressed the tv turns on for 1 second then shuts off again,when power button is pressed again it turns of for a few minutes then starts the process all over until the tv is allowed to cool down for a few hours. The standby LED light is not blinking so I cannot pull the codes,I found extensive cracked solder joints throughout the unit and I resoldered,the solder in the horizontal section was fine believe it or not but I resoldered it as well. This unit uses Flyback # 8-451-315-41 or 1-439-498-71 Here are other models which share the same chassis: Chassis: AA-1 Model : KV-27S10 / 15 KV-27TS29 / 29 / 32 / 36 KV-27TW77 / 78 KV-27V10 / 15 / 55 KV-27XBR37 / 45 KV-32S10 / 12 / 15 / 16 KV-32TS36 / 46 KV-32TW67 / 68 / 77 / 78 KV-32V15 / 16 KV-32XBR37 / 45 / 85 Taken from: http://www.iwaynet.net/~nesda/SonyCross.html Thanks in advance for help. |
#3
|
|||
|
|||
32' Sony tv KV-32V16,chassis:SCC-F85R-A
May want to chenk with Sony directly to see if there are any service
bulletins regarding this symptom. "Jerry G." wrote in message ... If the set shuts after it gets warmed up and will restart when cold, I would be looking for thermo sensitive components. The electrolytic caps in the scans and power supply in many sets are known for this type of fault. You can use a heat gun, and freeze-mist cooling spray to help troubleshoot for thermo sensitive components. Each time you cool the suspect parts, you will have to recycle the power, to see if it will start again. One method I use is to heat the suspect caps with a heat gun, and then test them with an ESR meter while they are still hot. This is a bit easier, depending on the accessibility of the underside of the board in this approach, and the situation. -- Greetings, Jerry Greenberg GLG Technologies GLG ============================================== WebPage http://www.zoom-one.com Electronics http://www.zoom-one.com/electron.htm Instruments http://www.zoom-one.com/glgtech.htm ============================================== "Sidney" wrote in message om... 32" Sony PIP stereo tv model:KV-32V16,chassis:SCC-F85R-A & AA-1,year:Nov 1995.After about 3 hours of running or so the tv shuts off and when power button is pressed the tv turns on for 1 second then shuts off again,when power button is pressed again it turns of for a few minutes then starts the process all over until the tv is allowed to cool down for a few hours. The standby LED light is not blinking so I cannot pull the codes,I found extensive cracked solder joints throughout the unit and I resoldered,the solder in the horizontal section was fine believe it or not but I resoldered it as well. This unit uses Flyback # 8-451-315-41 or 1-439-498-71 Here are other models which share the same chassis: Chassis: AA-1 Model : KV-27S10 / 15 KV-27TS29 / 29 / 32 / 36 KV-27TW77 / 78 KV-27V10 / 15 / 55 KV-27XBR37 / 45 KV-32S10 / 12 / 15 / 16 KV-32TS36 / 46 KV-32TW67 / 68 / 77 / 78 KV-32V15 / 16 KV-32XBR37 / 45 / 85 Taken from: http://www.iwaynet.net/~nesda/SonyCross.html Thanks in advance for help. |
#4
|
|||
|
|||
32' Sony tv KV-32V16,chassis:SCC-F85R-A
Symptom is consistent with a shorted picture tube in that model. Usually
the green gun but not always. Look for any sign of bright color image when it shuts down to confirm. Two things will allow the set to come up about3 to 5 seconds before shutdown (not xray protect which disables turn on attempt until unplugging tv). 1. Excessive beam current, shorted crt. 2. Loss of vertical return pulse to the system control, usually a vertical output problem. David Jerry G. wrote in message ... If the set shuts after it gets warmed up and will restart when cold, I would be looking for thermo sensitive components. The electrolytic caps in the scans and power supply in many sets are known for this type of fault. You can use a heat gun, and freeze-mist cooling spray to help troubleshoot for thermo sensitive components. Each time you cool the suspect parts, you will have to recycle the power, to see if it will start again. One method I use is to heat the suspect caps with a heat gun, and then test them with an ESR meter while they are still hot. This is a bit easier, depending on the accessibility of the underside of the board in this approach, and the situation. -- Greetings, Jerry Greenberg GLG Technologies GLG ============================================== WebPage http://www.zoom-one.com Electronics http://www.zoom-one.com/electron.htm Instruments http://www.zoom-one.com/glgtech.htm ============================================== "Sidney" wrote in message om... 32" Sony PIP stereo tv model:KV-32V16,chassis:SCC-F85R-A & AA-1,year:Nov 1995.After about 3 hours of running or so the tv shuts off and when power button is pressed the tv turns on for 1 second then shuts off again,when power button is pressed again it turns of for a few minutes then starts the process all over until the tv is allowed to cool down for a few hours. The standby LED light is not blinking so I cannot pull the codes,I found extensive cracked solder joints throughout the unit and I resoldered,the solder in the horizontal section was fine believe it or not but I resoldered it as well. This unit uses Flyback # 8-451-315-41 or 1-439-498-71 Here are other models which share the same chassis: Chassis: AA-1 Model : KV-27S10 / 15 KV-27TS29 / 29 / 32 / 36 KV-27TW77 / 78 KV-27V10 / 15 / 55 KV-27XBR37 / 45 KV-32S10 / 12 / 15 / 16 KV-32TS36 / 46 KV-32TW67 / 68 / 77 / 78 KV-32V15 / 16 KV-32XBR37 / 45 / 85 Taken from: http://www.iwaynet.net/~nesda/SonyCross.html Thanks in advance for help. |
Reply |
Thread Tools | Search this Thread |
Display Modes | |
|
|
Similar Threads | ||||
Thread | Forum | |||
Sony CDP-CX255 200 CD changer problems | Electronics Repair | |||
Sony G500 Monitor Repair | Electronics Repair | |||
Sony G500 Monitor Repair | Electronics Repair | |||
Lightening/cable surge = Sony TV problem | Electronics Repair | |||
Sony G410R Monitor problem (and bad Sony support) | Electronics Repair |