Sony XR-C5300, car radio -failed tuner block
Chuck wrote in message
...
On Sun, 6 Feb 2011 19:20:39 -0600, "Mark Zacharias"
wrote:
"N_Cook" wrote in message
...
Owner likes the 2 SW bands, other than find a broken one or related
model
also with the same tuner TUX-020 , any ideas?
Courtesy of some Danish and Polish threads someone found out that the
80
pin
Philips tuner IC TEA6842H is likely the same as the one badged Sony
8-759-653-23 in this tuner. All DC at the tuner 19 pins agree with Sony
Schema and rails, Xtal lines etc agree with the TEA... datasheet. There
is
local Xtal osc, serial data and clock line signals on engaging "SEEK" ,
front display shows changing f but the TEA pin 42 tuning V stays at
0.045V.
Nothing amiss DVMing around the variable cap diode , pushing IC pins if
loose, and no bad ESR local caps. Whatever occured happened in a garage
during a cold spell of weather, vehicle rarely used.
Try bringing in an external tuning voltage. If by varying this voltage
you
can get an IF output from the front end (and receive a channel at that
point...) then you know the front end transistors etc are OK and you
either
have a bad PLL chip or no oscillator sample going to the PLL chip.
Mark Z.
Just one more thing to check. Once you tune in a station, remove the
tuning voltage source. If the station stays tuned for a few seconds,
then you'll know the problem isn't caused by leaky varicaps. If the
frequency immediately drifts, the varicaps need to be replaced. Chuck
Interesting point to check, willdo
|