Electronics Repair (sci.electronics.repair) Discussion of repairing electronic equipment. Topics include requests for assistance, where to obtain servicing information and parts, techniques for diagnosis and repair, and annecdotes about success, failures and problems.

Reply
 
LinkBack Thread Tools Search this Thread Display Modes
  #1   Report Post  
Posted to sci.electronics.repair
external usenet poster
 
Posts: 2,163
Default 3 phase motor and VFD questions

I scrapped my GE washing machine. Actually, it scrapped itself when
the drum spider broke making repair too expensive to consider. But now
I have what appears to be a nice 3 phase motor. The specs are
ambiguous. The voltage is listed as variable. The frequencey is listed
as variable. The amperage is listed as 2.5 amps. So at least there's
that. It is quite heavy.
Since I removed all the electronics and the wiring harness I am
going to try to get the motor to run on the bench and then measure the
voltages at different speeds.
I have a pretty nice DVM but I don't know how well it will measure
AC voltage at frequencies much above 60 Hz. The meter will measure AC
frequency. But I'm guessing that the output from the washing machine
VFD is probably pretty far from a good sine wave. The VFD is a pretty
simple bare bones unit. Anybody know?
I do have a VFD that takes 120 volt single phase input and outputs
230 volts at up to 400 Hz. I would like to run the motor from it if I
can but what if the voltage is too high? Can the motor be run at too
high voltage for a while without damage? Will too high voltage just
cause overheating? Since the motor is VFD rated the insulation must be
pretty good so I'm thinking too high voltage is probably OK for at
least a few minutes.
If I can suss out what the original GE VFD expects for signals from
the washing machine control and am able to copy them I will do that.
But If I can't then I will want to try another VFD that I know how to
control.
There are at least two reasons I want to re-use this motor. One is
that I hate to throw out good stuff. It ****es me off to waste stuff.
Another reason to re-use the motor is that it is a high quality motor.
The way it was used in the washer to drive the drum required high
quality bearings and general high quality robust construction. The
drive belt tension was extremely high so this put a very high side
load on the front motor bearing and a high side load on the rear
bearing. The motor bearings still feel great and will probably last
forever.
I'm thinking that with the proper reduction the motor would make a
great motor for a small lathe and my son has a 9 inch South Bend that
would be much easier to use if it had infinite speed control.
Thanks,
Eric
  #2   Report Post  
Posted to sci.electronics.repair
external usenet poster
 
Posts: 138
Default 3 phase motor and VFD questions

On Sunday, December 29, 2019 at 3:14:20 PM UTC-5, wrote:
I scrapped my GE washing machine. Actually, it scrapped itself when
the drum spider broke making repair too expensive to consider. But now
I have what appears to be a nice 3 phase motor. The specs are
ambiguous. The voltage is listed as variable. The frequencey is listed
as variable. The amperage is listed as 2.5 amps. So at least there's
that. It is quite heavy.
Since I removed all the electronics and the wiring harness I am
going to try to get the motor to run on the bench and then measure the
voltages at different speeds.
I have a pretty nice DVM but I don't know how well it will measure
AC voltage at frequencies much above 60 Hz. The meter will measure AC
frequency. But I'm guessing that the output from the washing machine
VFD is probably pretty far from a good sine wave. The VFD is a pretty
simple bare bones unit. Anybody know?
I do have a VFD that takes 120 volt single phase input and outputs
230 volts at up to 400 Hz. I would like to run the motor from it if I
can but what if the voltage is too high? Can the motor be run at too
high voltage for a while without damage? Will too high voltage just
cause overheating? Since the motor is VFD rated the insulation must be
pretty good so I'm thinking too high voltage is probably OK for at
least a few minutes.
If I can suss out what the original GE VFD expects for signals from
the washing machine control and am able to copy them I will do that.
But If I can't then I will want to try another VFD that I know how to
control.
There are at least two reasons I want to re-use this motor. One is
that I hate to throw out good stuff. It ****es me off to waste stuff.
Another reason to re-use the motor is that it is a high quality motor.
The way it was used in the washer to drive the drum required high
quality bearings and general high quality robust construction. The
drive belt tension was extremely high so this put a very high side
load on the front motor bearing and a high side load on the rear
bearing. The motor bearings still feel great and will probably last
forever.
I'm thinking that with the proper reduction the motor would make a
great motor for a small lathe and my son has a 9 inch South Bend that
would be much easier to use if it had infinite speed control.
Thanks,
Eric


Did the washer run on 120 or 240? You should have saved the motor control board and the necessary parts of the harness.

The voltage and frequency aren't ambiguous, since the drive voltage has to change with the frequency.
  #3   Report Post  
Posted to sci.electronics.repair
external usenet poster
 
Posts: 633
Default 3 phase motor and VFD questions

On 12/29/19 3:17 PM, Michael Terrell wrote:
On Sunday, December 29, 2019 at 3:14:20 PM UTC-5, wrote:
Since I removed all the electronics and the wiring harness I am
going to try to get the motor to run on the bench and then measure the
voltages at different speeds. Did the washer run on 120 or 240? You should have saved the motor control

board and the necessary parts of the harness.


Do you even read what you reply to?


--
"I am a river to my people."
Jeff-1.0
WA6FWi
http:foxsmercantile.com
  #4   Report Post  
Posted to sci.electronics.repair
external usenet poster
 
Posts: 138
Default 3 phase motor and VFD questions

On Sunday, December 29, 2019 at 4:49:46 PM UTC-5, Fox's Mercantile wrote:
On 12/29/19 3:17 PM, Michael Terrell wrote:
On Sunday, December 29, 2019 at 3:14:20 PM UTC-5, wrote:
Since I removed all the electronics and the wiring harness I am
going to try to get the motor to run on the bench and then measure the
voltages at different speeds. Did the washer run on 120 or 240? You should have saved the motor control

board and the necessary parts of the harness.


Do you even read what you reply to?



Do you ever have a day without PMS? He said his VFD. He gave no information on the one that came with the motor, or if it was in good condition. His statement of 'trying to get it working' is rather vague. It may or may not operate like the stand alone VFD.

I was hoping to get more information out of him, but all you do is bitch. If he can get it to run from the existing drive, yes he can measure the frequency and voltage. From there, he can determine if his 120V VFD can be programmed for his needs.

VFDs aren't that complicated, but a lot of idiots can mess them up. I had to repair a pipe bender at a local Art Canopy factory. They had just moved, and hired a contractor to wire up their machinery. The idiot wired the 208/240 Volt machine to a single 120V circuit. You could stop the thing with your finger.

I made the idiot install the right breaker, then I added a boost transformer to run it off 240 to 245 volts. It ran twice as fast as it had, on 208V.

Aren't you supposed to be working on your latest plans to catch that #$%Z^7 Road Runner?
  #5   Report Post  
Posted to sci.electronics.repair
external usenet poster
 
Posts: 633
Default 3 phase motor and VFD questions

On 12/29/19 4:35 PM, Michael Terrell wrote:
I was hoping to get more information out of him, but all
you do is bitch.


And all you do, as usual, is act like an asshole, then make
the posting about you and how clever you are and how stupid
everyone else is.


--
"I am a river to my people."
Jeff-1.0
WA6FWi
http:foxsmercantile.com


  #6   Report Post  
Posted to sci.electronics.repair
external usenet poster
 
Posts: 4,045
Default 3 phase motor and VFD questions

On Sun, 29 Dec 2019 12:14:18 -0800, wrote:

I scrapped my GE washing machine. (...) But now
I have what appears to be a nice 3 phase motor.

(...)
I do have a VFD that takes 120 volt single phase input and outputs
230 volts at up to 400 Hz.


Most VFD's can be jumpered for either 120 or 240VAC. Maker and model
number would be helpful here.

I would like to run the motor from it if I
can but what if the voltage is too high?


If the voltage is too high, you'll burn up either the VFD, motor, or
both.

Can the motor be run at too
high voltage for a while without damage?


No. You'll burn up the motor or burn up the VFD from too much
current.

Will too high voltage just
cause overheating?


Yes. You will rapidly begin sweating profusely as the motor begins
performing a rapid self-disassembly.

I'm thinking that with the proper reduction the motor would make a
great motor for a small lathe and my son has a 9 inch South Bend that
would be much easier to use if it had infinite speed control.


Washing machine motors are usually 1/2 or 3/4 horsepower. The South
Bend 9" light duty (10K) lathe will suffice with a 3/4 hp motor. The
9" heavy duty flavor (10L) lathe might need a 1 hp motor. Bigger is
always better:
http://www.chaski.org/homemachinist/viewtopic.php?t=83521
I'm not sure about the RPM but you should be able to extract it from
the existing motor's nameplate. Mo
https://www.practicalmachinist.com/vb/south-bend-lathes/what-correct-9a-motor-size-238473/
https://groups.google.com/forum/#!topic/rec.crafts.metalworking/uHEsa0IHoxI
etc. Lots more on SB lathe motors, etc found with Google.

You'll probably also need a spindle speed tachometer. Something like
this:
https://www.ebay.com/itm/332908532113

--
Jeff Liebermann

150 Felker St #D
http://www.LearnByDestroying.com
Santa Cruz CA 95060 http://802.11junk.com
Skype: JeffLiebermann AE6KS 831-336-2558
  #7   Report Post  
Posted to sci.electronics.repair
external usenet poster
 
Posts: 1,625
Default 3 phase motor and VFD questions


3-phase motor on a washing machine? Must be an industrial device, not hardly an over-the-counter consumer device.

With that in mind, you will need a simple 3-phase VFD, as a single device. They may be had with little fuss and at a reasonable cost. Such as:

https://www.automationdirect.com/adc...CZ6kQAvD_B wE

Only one of many options.

Do check that the motor is well-and-truly 3-phase, however.

Peter Wieck
Melrose Park, PA
  #8   Report Post  
Posted to sci.electronics.repair
external usenet poster
 
Posts: 2,163
Default 3 phase motor and VFD questions

On Sun, 29 Dec 2019 17:34:08 -0800, Jeff Liebermann
wrote:

On Sun, 29 Dec 2019 12:14:18 -0800, wrote:

I scrapped my GE washing machine. (...) But now
I have what appears to be a nice 3 phase motor.

(...)
I do have a VFD that takes 120 volt single phase input and outputs
230 volts at up to 400 Hz.


Most VFD's can be jumpered for either 120 or 240VAC. Maker and model
number would be helpful here.

I would like to run the motor from it if I
can but what if the voltage is too high?


If the voltage is too high, you'll burn up either the VFD, motor, or
both.

Can the motor be run at too
high voltage for a while without damage?


No. You'll burn up the motor or burn up the VFD from too much
current.

Will too high voltage just
cause overheating?


Yes. You will rapidly begin sweating profusely as the motor begins
performing a rapid self-disassembly.

I'm thinking that with the proper reduction the motor would make a
great motor for a small lathe and my son has a 9 inch South Bend that
would be much easier to use if it had infinite speed control.


Washing machine motors are usually 1/2 or 3/4 horsepower. The South
Bend 9" light duty (10K) lathe will suffice with a 3/4 hp motor. The
9" heavy duty flavor (10L) lathe might need a 1 hp motor. Bigger is
always better:
http://www.chaski.org/homemachinist/viewtopic.php?t=83521
I'm not sure about the RPM but you should be able to extract it from
the existing motor's nameplate. Mo
https://www.practicalmachinist.com/vb/south-bend-lathes/what-correct-9a-motor-size-238473/
https://groups.google.com/forum/#!topic/rec.crafts.metalworking/uHEsa0IHoxI
etc. Lots more on SB lathe motors, etc found with Google.

You'll probably also need a spindle speed tachometer. Something like
this:
https://www.ebay.com/itm/332908532113

I'll need to check my VFD to see if it can be jumpered to output
120 volts. I couldn't remember if more voltage would cause more
current. Thanks.
Since my son is doing light duty work with the lathe 1/2 HP should
be fine. And the motor he is using now is 1/2 hp. It's just a standard
single phase induction motor though. The washing machine motor has a
tach so that's covered. If I can get the existing VFD to work out of
the washer.
Cheers,
Eric
  #9   Report Post  
Posted to sci.electronics.repair
external usenet poster
 
Posts: 2,163
Default 3 phase motor and VFD questions

On Mon, 30 Dec 2019 05:08:34 -0800 (PST), "
wrote:


3-phase motor on a washing machine? Must be an industrial device, not hardly an over-the-counter consumer device.

With that in mind, you will need a simple 3-phase VFD, as a single device. They may be had with little fuss and at a reasonable cost. Such as:

https://www.automationdirect.com/adc...CZ6kQAvD_B wE

Only one of many options.

Do check that the motor is well-and-truly 3-phase, however.

Peter Wieck
Melrose Park, PA

As I stated in my post I do have already a VFD that would work except
that I think it only outputs 120 volts. And the motor nameplate says
on it that it is a 3 phase induction motor. The voltage and frequency
are listed as being variable. But Jeff L. suggested that it may be
jumperable so I will need to check the manual. I didn't even think it
may be able to output 120 volts.
Cheers,
Eric
  #10   Report Post  
Posted to sci.electronics.repair
external usenet poster
 
Posts: 138
Default 3 phase motor and VFD questions

On Monday, December 30, 2019 at 8:08:36 AM UTC-5, wrote:
3-phase motor on a washing machine? Must be an industrial device, not hardly an over-the-counter consumer device.

With that in mind, you will need a simple 3-phase VFD, as a single device.. They may be had with little fuss and at a reasonable cost. Such as:

https://www.automationdirect.com/adc...CZ6kQAvD_B wE

Only one of many options.

Do check that the motor is well-and-truly 3-phase, however.



So called 'High efficiency' washers have them, and so do some window Air conditioners. They eliminate the need for a fancy gearbox and they can reverse direction easily. A smaller motor can be used in some cases. Variable speed is used to reduce energy use on smaller loads.


  #11   Report Post  
Posted to sci.electronics.repair
external usenet poster
 
Posts: 1,625
Default 3 phase motor and VFD questions

https://www.youtube.com/watch?v=ASPwNEtSzK8

Peter Wieck
Melrose Park, PA
Reply
Thread Tools Search this Thread
Search this Thread:

Advanced Search
Display Modes

Posting Rules

Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are On
Pingbacks are On
Refbacks are On


Similar Threads
Thread Thread Starter Forum Replies Last Post
Need help with 3-Phase Lathe motor VFD error please PCS Metalworking 13 August 24th 13 04:51 PM
3-phase used for 1-phase (split-phase) power SRK Home Repair 9 July 22nd 06 11:01 AM
VFD and 3 phase motor for the 4x6 HF bandsaw carl mciver Metalworking 2 February 20th 06 02:15 AM
VFD versus Phase Converter versus 3-phase power Jay Pique Woodworking 8 October 28th 05 12:36 AM
5 hp 3 phase motor to a 3/4 hp single phase..? Paul Metalworking 33 March 23rd 04 07:23 PM


All times are GMT +1. The time now is 08:42 PM.

Powered by vBulletin® Copyright ©2000 - 2024, Jelsoft Enterprises Ltd.
Copyright ©2004-2024 DIYbanter.
The comments are property of their posters.
 

About Us

"It's about DIY & home improvement"